Potentials of Citrus sinensis seed oil were evaluated for its biodiesel and lubricating properties. The oil of C. sinensis seed was extracted using n-hexane and then transesterified using various methanol: oil ratios. The physicochemical properties of the oil and the resultant biodiesel, such as viscosity, acid value, iodine value, free fatty acid value, pour point, cloud point, smoke point, specific gravity and surface tension, were determined. The raw oil exhibited a low oxidative stability, while the biodiesel ratio with the highest methanol content had a biodiesel potential that could compete favourably with that of fossil diesel. The test for the burning efficiency of the respective biodiesel ratios indicated that the ratio with the lowest alcohol content had the best burning efficiency. This was evident from its relatively low flash point. The study concluded that the non-edible oil obtained from the seeds of C. sinensis could serve as a highly reliable substitute for the production of very good quality biodiesel fuels.
| Published in | International Journal of Bioorganic Chemistry (Volume 4, Issue 2) |
| DOI | 10.11648/j.ijbc.20190402.11 |
| Page(s) | 84-92 |
| Creative Commons |
This is an Open Access article, distributed under the terms of the Creative Commons Attribution 4.0 International License (http://creativecommons.org/licenses/by/4.0/), which permits unrestricted use, distribution and reproduction in any medium or format, provided the original work is properly cited. |
| Copyright |
Copyright © The Author(s), 2019. Published by Science Publishing Group |
Biodiesel, Lubricating Properties, Seed Oil, Citrus Sinensis, Physicochemical Properties
| [1] | D. A. Wardle, D. A. (2003), Global sale of green air travel supported using Biodiesel. Renew. Sustainable Energy Rev. 7 (2003) 1–64. |
| [2] | S. K. Otoikhian, E. O. Aluyor, T. O. K. Audu, Two-Steps Transesterification of Hura crepitans Seed Oil using Polymer Based Catalyst. Walailak Journal Sci. Tech. 13 (2016) 931 - 937. |
| [3] | J. D. A. Kpana, J. Krahl, The impact of adsorbents on the oxidative stability of biodiesel and its influence on the deterioration of engine oil. Fuel 256 (2019) 115984. |
| [4] | J. Sheehan, V. Camobreco, J. Duffield, M. Graboski, H. Shapouri. Life cycle inventory of biodiesel and petroleum diesel for use in an urban bus. Final report. No. NREL/SR--580-24089. National Renewable Energy Lab., Golden, CO (US), 1998. |
| [5] | G. G. Pearl, Animal fat potential for bioenergy use. Bioenergy 2002, the tenth biennial bioenergy conference, Biose, ID, sept. 22-26, 2002. |
| [6] | S. Banerjee, S. Rout, S. Banerjee, A. Attad, D. Das, Fe2O3 nanocatalyst aided transesterification for biodiesel production from lipid-intact wet microalgal biomass: A biorefinery approach. Energy Conversion and Management 195 (2019) 844–853. |
| [7] | L. R. Rudnick, Additives for industrial lubricant applications. Lubricant Additives Chemistry and Applications. CRC Press Taylor & Francis Group, Florida, 2009. |
| [8] | G. Knothe, Historical perspectives on vegetable oil-based diesel fuels. INFORM, 12 (2001) 1103-1107. |
| [9] | N. L. Boschen, M. G. P. Valenga, G. A. R. Maia, A. L. Gallina, P. R. P. Rodrigues, Synergistic study of the antioxidant potential of barley waste for biodiesel. Industrial Crops & Products 140 (2019) 111624. |
| [10] | M. Canaci, A. N. Ozsezen, E. Arcaklioglu, A. Erdil, Prediction of performance and exhaust emissions of a diesel engine fuelled with biodiesel produced from waste frying palm oil, Expert Sys. Appl., 36 (2009) 9268-9280, doi: 10.1016/j.eswa.2008.12.005. |
| [11] | Chrysler, E. D., Drive New Diesels Running on Renewable Fuel.". National Biodiesel Board, 2011, pp. 188. |
| [12] | S. S. Hoseini, G. Najafi, A. Sadeghi. Chemical characterization of oil and biodiesel from Common Purslane (Portulaca) seed as novel weed plant feedstock. Industrial Crops & Products 140 (2019) 111582. |
| [13] | D. A. Kamel, H. A. Farag, N. K. Amin, A. A. Zatout, R. M. Ali 2018. Smart utilization of jatropha (Jatropha curcas Linnaeus) seeds for biodiesel production: optimization and mechanism. Ind. Crops Prod. 111 (2018) 407–413. |
| [14] | Q. Rana, M. L. Rehman, M. Irfan, S. Ahmed, F. Hasan, A. A. Shah, S. Khan, M. Badshah (in press). Lipolytic bacterial strains mediated transesterification of non-edible plant oils for generation of high quality biodiesel. Journal of Bioscience and Bioengineering (2018) 1-9. |
| [15] | Y. Kawahara, T. Ono. Process for producing lower alcohol esters of fatty acids, US Patent No. 4, 164-506, 1979. |
| [16] | S. Singh, D. Singh, D. Biodiesel production through the use of different sources and characterization of oils and their esters as the substitute of diesel: a review. Renew. Sustain. Energy Rev. 14 (2010) 200–216. |
| [17] | J. A. O. Oyekunle, A. A. Omode, Chemical composition and fatty acid profile of the lipid fractions of selected Nigerian indigenous oilseeds. Int. J. Food Prop. 11 (2008) 273–281. |
| [18] | G. Knothe, Structure indices in FA chemistry, How relevant is the iodine value? J. Am. Oil Chem. Soc., 79 (2002) 847-854. |
| [19] | M. kaieda, T. Samukawa, T. Matsumoto, K. Ban, A. Kondo, Y. Shimada, H. Noda, F. Nomoto, K. Ohtsuka, E. Izumoto, H. Fukuda, Biodiesel Fuel production from plant oil catalyzed by Rhizopus oryzae lipase in a water-containing system without an organic solvent, J. Biosci. Bioeng. 88 (1999) 627-631. |
| [20] | B. Berry. Sunday night spotlight: Orange essential oil. Bramble Berry News. https://www.soapqueen.com/bramble-berry-news/sunday-night-spotlight-orange-essential-oil/. 2014. |
| [21] | AOAC, Association of Official Analytical Chemists. Official Methods of the Association of Official Analytical Chemists, fifteenth edition, 2004, pp. 955–972. |
| [22] | J. Van Gerpen, B. Shanks, R. Pruszko, D. Clements, G. Knothe, Biodiesel Analytical Methods. National Renewable Energy Laboratory, 2004. |
| [23] | T. Leevijit, P. Gumpon, M. Kittinan, M. Parinya, O. Sakdinan, E. Suppakit, Production, properties, and utilization of degummed/esterified mixed crude palm oil-diesel blends in an automotive engine without preheating. Fuel 182 (2016) 509–516. |
| [24] | J. D. Udonne, A comparative study of recycling of used lubrication Oils using distillation, acid and activated charcoal with clay methods. J. Pet. Gas Eng. 2 (2011) 12-19. |
| [25] | ASTM. American Society of Testing and Materials. ASTM D6751-02 Requirements for biodiesel ASTM, Easton, Maryland, USA. |
| [26] | T. H. Gourd, J. C. Vulgter and C. J. A. Roelands, Physical properties of fatty acid methyl esters vi-viscosity. J. Am. Oil Chem. Soc., 16 (1966) 433-434. |
| [27] | ASTM. American Society of Testing and Materials. ASTM D1310-14. Standard test for flash point and fire points of liquids by tag-open cup apparatus. Book of standards. 6:1. |
| [28] | D. Kumar, T. Das, B. S. Giri, B. Verma, Preparation and characterization of novel hybrid bio-support material immobilized from Pseudomonas cepacia lipase and its application to enhance biodiesel production. Renewable Energy 147 (2020) 11-24. |
| [29] | L. F. Ramírez-Verduzco. Models for predicting the surface tension of biodiesel and methyl esters. Renewable and Sustainable Energy Reviews 41 (2015) 202–216. |
| [30] | F. Daniels, and R. A. Alberty, Physical Chemistry, Second Edition. John Wiley &Sons, Incorporation, New York, 1961. |
| [31] | Bikerman, J. Jacob, Surface Chemistry. 2nd Edition, Academic Press, Incorporation, 1958, pp. 1-128. |
| [32] | S. N. Sahasrabudhe, V. Rodriguez-Martinez, M. O’Meara, B. E. Farkas. Density, viscosity, and surface tension of five vegetable oils at elevated temperatures: Measurement and modeling. International Journal of Food Properties, 20 (2017) 1965-1981, DOI: 10.1080/10942912.2017.1360905. |
| [33] | Bal Seal Engineering. The Effect of Wet Lubrication on BalTM Seal Performance. Technical Report, 2001. |
| [34] | N. Boz, K. Miray, O. Sunal, E. Alptek N. De˘g˙irmenbasi, Investigation of the fuel properties of biodiesel produced over an alumina-based solid catalyst. Turk. J. Chem. 33 (2009) 433-442. |
| [35] | CODEX Alimentarius Commissions, Recommended International Standards For Edible Arachis Oil. Food and Agricultural Organization of the United Nation. World Health Organization, Geneva, Switzerland. 1 (1992) 6-19. |
| [36] | L. Du, Z. Li, S. Ding, C. Chen, S. Qu, W. Yi, J. Lu, J. Ding. Synthesis and characterization of carbon-based MgO catalysts for biodiesel production from castor oil. Fuel 258 (2019) 116122. |
| [37] | F. A. Olokodana, Analysis of Fats and Oils: 2-Day Mandatory Workshop on Sample Preparation For The Analysis Of Foods-Raw And Processed, 3rd-4th Dec. 2003, Lagos Institute Of Public Analysts of Nigeria (IPAN), 2003, pp. 17-44. |
| [38] | K. Salles, S. M. P. Meneghetti, W. Ferreira de La Salles, M. R. Meneghetti, I. C. F. dos Santos, J. P. V. da Silva, S. H. V. de Carvalho, J. I. Soletti, Characterization of Syagrus coronata (Mart.) Becc. oil and properties of methyl esters for use as biodiesel. Ind. Crop Prod, 32 (2010) 518–521. |
| [39] | A. S. Adekunle, J. A. O. Oyekunle, O. R. Obisesan, O. S. Ojo, Effects of Degumming on the Biodiesel Properties of some Non-conventional Seed oils. Energy Report, 21 (2016) 88-193, http://dx.doi.org/10.1016/j.egyr.2016.07.001. |
APA Style
John Adekunle Oyedele Oyekunle, Saheed Eluwale Elugoke, Abolanle Saheed Adekunle, Oluwaseyi Samson Ojo, Adeniyi Jide Oyinloye, et al. (2019). Biodiesel Potentials and Lubricating Properties of Citrus sinensis Seed Oil. International Journal of Bioorganic Chemistry, 4(2), 84-92. https://doi.org/10.11648/j.ijbc.20190402.11
ACS Style
John Adekunle Oyedele Oyekunle; Saheed Eluwale Elugoke; Abolanle Saheed Adekunle; Oluwaseyi Samson Ojo; Adeniyi Jide Oyinloye, et al. Biodiesel Potentials and Lubricating Properties of Citrus sinensis Seed Oil. Int. J. Bioorg. Chem. 2019, 4(2), 84-92. doi: 10.11648/j.ijbc.20190402.11
AMA Style
John Adekunle Oyedele Oyekunle, Saheed Eluwale Elugoke, Abolanle Saheed Adekunle, Oluwaseyi Samson Ojo, Adeniyi Jide Oyinloye, et al. Biodiesel Potentials and Lubricating Properties of Citrus sinensis Seed Oil. Int J Bioorg Chem. 2019;4(2):84-92. doi: 10.11648/j.ijbc.20190402.11
Share This Article
Twitter
Linked In
Facebook
Copy
Download@article{10.11648/j.ijbc.20190402.11,
author = {John Adekunle Oyedele Oyekunle and Saheed Eluwale Elugoke and Abolanle Saheed Adekunle and Oluwaseyi Samson Ojo and Adeniyi Jide Oyinloye and Omowumi Temitope Fakoya and Olaoluwa Ruth Obisesan and Solomon Sunday Durodola},
title = {Biodiesel Potentials and Lubricating Properties of Citrus sinensis Seed Oil},
journal = {International Journal of Bioorganic Chemistry},
volume = {4},
number = {2},
pages = {84-92},
doi = {10.11648/j.ijbc.20190402.11},
url = {https://doi.org/10.11648/j.ijbc.20190402.11},
eprint = {https://article.sciencepublishinggroup.com/pdf/10.11648.j.ijbc.20190402.11},
abstract = {Potentials of Citrus sinensis seed oil were evaluated for its biodiesel and lubricating properties. The oil of C. sinensis seed was extracted using n-hexane and then transesterified using various methanol: oil ratios. The physicochemical properties of the oil and the resultant biodiesel, such as viscosity, acid value, iodine value, free fatty acid value, pour point, cloud point, smoke point, specific gravity and surface tension, were determined. The raw oil exhibited a low oxidative stability, while the biodiesel ratio with the highest methanol content had a biodiesel potential that could compete favourably with that of fossil diesel. The test for the burning efficiency of the respective biodiesel ratios indicated that the ratio with the lowest alcohol content had the best burning efficiency. This was evident from its relatively low flash point. The study concluded that the non-edible oil obtained from the seeds of C. sinensis could serve as a highly reliable substitute for the production of very good quality biodiesel fuels.},
year = {2019}
}
TY - JOUR T1 - Biodiesel Potentials and Lubricating Properties of Citrus sinensis Seed Oil AU - John Adekunle Oyedele Oyekunle AU - Saheed Eluwale Elugoke AU - Abolanle Saheed Adekunle AU - Oluwaseyi Samson Ojo AU - Adeniyi Jide Oyinloye AU - Omowumi Temitope Fakoya AU - Olaoluwa Ruth Obisesan AU - Solomon Sunday Durodola Y1 - 2019/12/06 PY - 2019 N1 - https://doi.org/10.11648/j.ijbc.20190402.11 DO - 10.11648/j.ijbc.20190402.11 T2 - International Journal of Bioorganic Chemistry JF - International Journal of Bioorganic Chemistry JO - International Journal of Bioorganic Chemistry SP - 84 EP - 92 PB - Science Publishing Group SN - 2578-9392 UR - https://doi.org/10.11648/j.ijbc.20190402.11 AB - Potentials of Citrus sinensis seed oil were evaluated for its biodiesel and lubricating properties. The oil of C. sinensis seed was extracted using n-hexane and then transesterified using various methanol: oil ratios. The physicochemical properties of the oil and the resultant biodiesel, such as viscosity, acid value, iodine value, free fatty acid value, pour point, cloud point, smoke point, specific gravity and surface tension, were determined. The raw oil exhibited a low oxidative stability, while the biodiesel ratio with the highest methanol content had a biodiesel potential that could compete favourably with that of fossil diesel. The test for the burning efficiency of the respective biodiesel ratios indicated that the ratio with the lowest alcohol content had the best burning efficiency. This was evident from its relatively low flash point. The study concluded that the non-edible oil obtained from the seeds of C. sinensis could serve as a highly reliable substitute for the production of very good quality biodiesel fuels. VL - 4 IS - 2 ER -
Information
Email: